Metal Roof Repair in Carmel Valley CA 93924

Locally Owned & Operated

HOME PROS ROOFING

Looking for the right Roofing company for your home or property? Since 1980 we have been providing Roofing services to the Carmel Valley area.

(844) 359-2189

(Carmel Valley CA 93924) –

In an earlier article we looked at elastomeric roof coatings like Kool Seal to perform some preventative maintenance and to seal small pin holes on shipping container roofs. In addition, the light color roof coatings also reduce the heat island effect and the heat buildup on the inside of your container often caused by a darker painted or rusted container roof. With its main purpose being to keep the elements out, shipping container Be Careful! Carmel Valley CA 93924 roofs are the weak link in the whole structure. Shipping container walls are constructed from heavy-duty 14 gauge weathering steel and the posts are fabricated from 7 gauge tube steel but the roof of shipping containers is constructed with 16 to 18 gauge die-stamp corrugated steel sheets. These roofs have very limited load bearing capacity, any loading on containers is meant to be distributed to the ground (or boat deck) by the four Carmel Valley CA 93924 corner posts, not the roof.

Often shipping containers may get a dented roof due to handling while being loaded or unloaded from cargo ships. Should the containers roof get a dent in it where water can puddle it should be repaired before it rusts through. If you do find that you have water entering the container, the best fix is to remove the damaged portion of the roof and weld in a new steel How to Minimize Your Roof Repair Cost Carmel Valley CA 93924 roof panel section, however in some situations this is easier said than done. If the if the proper tools and equipment are not available then you need an alternate but permanent repair.

In the modular building industry we have had a great deal of success using a product called EternaBond to permanently seal the roof seams between building sections. EternaBond works on both metal and EPDM surfaces and it is used over and over Carmel Valley CA 93924 again to join the roof seams on rented modular buildings. Modular buildings are delivered, set up, and used in sometimes caustic environments like chemical plants for several years. When the rental is over the roof seam is cut, the building modules pulled apart then sent to a new site where another slightly wider layer of EternaBond tape is installed right over the top of the old tape seam because the preceding layer is Carmel Valley CA 93924 to difficult and time-consuming to remove. As the roofs aged and deteriorated with several layers of abandoned seam material a new EternaBond tape layer rarely failed us.

EternaBond is a rubber tape product with adhesive on one side. To install it you clean the surface, brush a primer product on the surface, apply an adhesive to the surface then press on the EternaBoond tape. You will immediately have a long-lasting water tight roof patch. Carmel Valley CA 93924 For added protection you can apply an EtrnaBond chalk to the edges of the patch. EternaBond is available in 50′ rolls starting at 2″ wide going up to 48″ wide so you can find an EternaBond product for almost any container roof patching need, both emergency and permanent.

Video: Metal Roof Seam Repair

Video: Replace Problem Metal Roofing Boot - No More Leak in 5V crimp Roof

Video: Stop water leakage through metal roof

Video: Metal Roof Repair - Metal Over Metal Using Roof Hugger

Video: Metal Roof Repair Old Orchard Beach ME

Video: Easy Metal Roof Repair Using "Maximum Stretch" Spray On Coating by AmesResearch.com

Business Results 1 - 10 of 4

Dority Roofing & Solar
11 Reviews
Roofing, Solar Installation, Waterproofing
Phone:
2106 Sunset Dr, Pacific Grove, CA 93950

H2o Proofing Services
36 Reviews
Roofing, Damage Restoration, Waterproofing
Phone:
Moss Landing, CA 95039

Williams Roofing
10 Reviews
Roofing
Phone:
11125 Commercial Pkwy, Castroville, CA 95012

831 Heating & Sheetmetal
9 Reviews
Heating & Air Conditioning/HVAC, Metal Fabricators
Phone:
Salinas, CA 93901

GET A QUOTE NOW

For quality workmanship and service for your residential and commercial Roofing needs, choose a company with over 38 years of service in the Carmel Valley area.

Highly Rated

Integrity, quality workmanship and attention to detail have made us one of the most reliable Roofing companies in Carmel Valley.

Quality Service

We focus on making the process as least disruptive as possible to our clients

Affordable Prices

We work hard to keep our costs low and transfer these efficiency savings on to our customers

100% California Licensed Experts

We can complete any size project  in a timely manner, without skipping any steps  or cutting any corners.

GET A QUOTE NOW

(844) 359-2189